P0455 on a 2017 Kia Sorento
EVAP Large or Gross Leak Detected
P0455 on a 2017 Kia Sorento indicates evap large or gross leak detected. It usually stays drivable short-term but should be diagnosed promptly. The most common cause is missing, loose, or wrong-fit fuel cap (typically $0–$60). Confirm the root cause before replacing parts.
What does P0455 mean on a 2017 Kia Sorento?
P0455 is set when the EVAP system's gross-leak monitor detects an opening approximately 0.090 inches (2.3 mm) or larger — or in many cases, no seal at all. This is the size of a missing gas cap, a disconnected hose, or a failed vent solenoid stuck open. The system cannot hold pressure or vacuum for the calibration period, so the ECM concludes a major leak.
This guide covers P0455 across the 2015-2019 Kia Sorento generation — the symptoms, causes, and diagnostic steps below apply to every model year from 2015 through 2019.
Is it safe to drive a 2017 Kia Sorento with P0455?
In most cases a 2017 Kia Sorento stays drivable for short trips with P0455 active, but diagnose and repair it promptly. This is a low-severity code — ignoring it can lead to further damage or a failed emissions test.
What are the symptoms of P0455 on a 2017 Kia Sorento?
- Check Engine Light is illuminated
- Distinct fuel smell, especially after refueling
- Fuel-cap warning message on the dashboard on some vehicles
- No drivability issue
- Vehicle will fail emissions / smog testing
What causes P0455 on a 2017 Kia Sorento?
| Cause | Likelihood | Estimated repair (USD) |
|---|---|---|
| Missing, loose, or wrong-fit fuel cap Always check first. A locking gas cap from another vehicle that almost fits is a common source. | Most common | $0–$60 |
| Disconnected or split EVAP hose | Common | $30–$200 |
| EVAP vent valve stuck open (will not seal during the monitor test) | Common | $80–$350 |
| Damaged or rusted-through fuel filler neck | Occasional | $200–$700 |
| Cracked or broken EVAP charcoal canister | Occasional | $200–$600 |
| Damaged O-ring at the fuel pump assembly cover | Rare | $30–$500 |
| Rodent damage to EVAP hoses (parked vehicles) | Occasional | $30–$200 |
How to diagnose this on a 2017 Kia Sorento
-
Check the gas cap is present and correctly seated
Confirm the cap is the correct OEM cap for the vehicle. Many generic-fit replacement caps look identical but have slightly wrong gasket geometry. Hand-tighten to at least 3 clicks. Some vehicles flag a missing cap as P0455 within one drive cycle.
Tools: None
-
Visually inspect the EVAP hoses near the canister
On most trucks and SUVs the EVAP canister sits behind the rear bumper or above the rear axle. Inspect every hose from the canister to the tank vent and to the purge solenoid. Pay particular attention to rodent damage on parked vehicles.
Tools: Floor jack and stands, Flashlight
-
Smoke-test the EVAP system at low pressure
Introduce smoke at 0.5 psi through the service port. With a large leak the smoke will pour visibly from the failure point within seconds. If smoke escapes from the vent solenoid even with the solenoid commanded closed, replace the solenoid.
Tools: EVAP smoke machine
-
Test the EVAP vent valve function
Disconnect the vent valve and apply 12 V — it should click and close. Hold a hand vacuum pump to one port and verify the valve holds vacuum when energized. A vent valve that does not close fully will set P0455 because the system can never seal.
Tools: 12 V test source, Hand vacuum pump
-
Inspect the fuel filler neck and tank-top seals
Rust-belt vehicles often develop pinholes or seam separation in the metal portion of the fuel filler neck. Once the rust is through, the EVAP system cannot hold any vacuum. Replacement is the only fix.
Tools: Floor jack and stands, Inspection mirror
NHTSA complaints & recalls for the 2017 Kia Sorento
Owner-reported safety complaints and official recalls filed with the U.S. National Highway Traffic Safety Administration for the 2017 Kia Sorento. Use these to gauge how common a problem is on your specific vehicle before you start chasing Kia Sorento diagnostics.
- ENGINE 374
- EXTERIOR LIGHTING 124
- UNKNOWN OR OTHER 101
- STEERING 94
- ELECTRICAL SYSTEM 91
4 active recalls
- FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS Dec 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The h…
NHTSA campaign 18V907000 - ENGINE AND ENGINE COOLING:ENGINE Sep 2017
Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.…
NHTSA campaign 17V586000 - TRAILER HITCHES Nov 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitc…
NHTSA campaign 16V862000 - TRAILER HITCHES Sep 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia d…
NHTSA campaign 22V703000
How do I fix P0455 on a 2017 Kia Sorento?
- Replace the fuel cap
- Replace the EVAP vent valve / vent solenoid
- Replace damaged EVAP hoses
- Replace the EVAP charcoal canister
- Replace the fuel filler neck
About the 2015-2019 Kia Sorento
The 2015-2019 Kia Sorento was commonly sold with the following powertrains: 2.5L I4, 2.5L Turbo I4, 1.6L Turbo Hybrid I4, 1.6L Plug-in Hybrid I4. Common trims include LX, S, EX, SX, SX-Prestige, X-Line.
How fast P0455 sets after a missing cap
Most OBD-II vehicles flag P0455 within one cold-start drive cycle after the cap is left off. Some Ford and GM vehicles will set a more specific “check fuel cap” message first and only escalate to P0455 if the issue persists across multiple drive cycles.
P0455 right after winter on a parked vehicle
Mice and rats chew EVAP hoses to nest inside the canister or near the fuel tank. If P0455 appears on a vehicle that has been parked for the winter, inspect every accessible EVAP hose for clean-edged bite marks before buying parts. This pattern is so common on rural-parked trucks that several shop forums have dedicated threads.
The cap that “fits” but doesn’t seal
A locking gas cap from a similar-vintage vehicle in the same brand family often threads on but seals against the filler neck at the wrong depth or angle. The result is repeated P0455 codes after every refuel. If the cap has been replaced and the code persists, double-check it is the exact OEM part number for this vehicle.